دریافت یک نقل قول

utilization of textile sludge in geopolymer concrete

ما

utilization of textile sludge in geopolymer concrete

EXPERIMENTAL INVESTIGATION OF GEOPOLYMER …

Jahagirdar (2015) Study deals with reuse of textile mill sludge in making cement bases solid blocks which can be used in practice for bulk usage of sludge. Textile sludge and fly ash are analyzed by using XRF technique. Textile sludge is mixed with cement and later with combination of cement and fly ash to make solid blocks.

ادامه مطلب

Feasibility Study of the Use of Concrete Sludge As ...

This study aims to examine the use of concrete sludge from water treatment installations of ready-mixed concrete plants as an alternative raw material for portland clinker kilns, and to enumerate possible limitations. By its extensive and representative collection of concrete sludge samples data, it may also be used for other investigations.

ادامه مطلب

Technical Committee on Application of Geopolymer ...

learning to explain the outline of geopolymer to engineers and students with basic knowledge of concrete. WG3: Manufacture and Construction – 1) collecting domestic and international case studies regarding practical use of geopolymer (factory products, on-site construction, etc.).

ادامه مطلب

Review on Adsorption of Heavy Metal in Wastewater by …

Currently, geopolymer gain new interest to treat wastewater and replacing the conventional adsorbent use which normally used in the production of cement. First identification of geopolymeric materials as an alternative to conventional Portland cement and concrete composites in 1979 [7]. Geopolymer can be viewed as an economic zeolite

ادامه مطلب

COMPLETE RECYCLING AND UTILIZATION OF WASTE …

utilization of concrete aggregates in low-specification applications such as base course and non-structure filling [8-10]. Generally, the waste concrete crushing process generates both aggregates (coarse and fine) and fines. The concrete aggregate (called recycled aggregate – RA later) contains

ادامه مطلب

Research progress on mechanical properties of geopolymer ...

The results show that the use of recycled geopolymer concrete aggregates to replace rough natural aggregates by up to 20% will significantly reduce the elastic modulus, flexural strength and compressive strength of OPC. At this time, the compressive strength is 50 MPa, which is 10% lower than the standard group, shown in Figure 9 . Moreover ...

ادامه مطلب

[PDF] Utilization of Brine Sludge in Non-Traffic Paver ...

In the present work, brine sludge is mixed in M30 Concrete mix of paver blocks. A paver is a paving-stone, tile, brick or brick-like piece of concrete which is commonly used as exterior flooring, footpaths and as non-traffic constructions. In the factories, concrete paver blocks are made by pouring a mixture of concrete and some different type of colouring agents into moulds of some shape and ...

ادامه مطلب

Infrastructures | Special Issue : Durability of Concrete ...

This study was conducted on concrete using sewage sludge ash (SSA) with the aim to establish an efficient use of SSA as a cement replacement material. Concrete specimens with three degrees of strength were made from two different SSAs and exposed in temperate plain and cold mountain regions for a prolonged period of time to investigate the long ...

ادامه مطلب

project_waste_management.pdf - Faculty of Chemical and ...

Use of textile ETP sludge up to a maximum of 30% substitution for cement may be possible in the manufacture of nonstructural building materials. Several researchers reported that the slag obtained from different sources can be utilized as a supplementary raw material in different construction applications.

ادامه مطلب

PHUFRQFUHWH DUHYLHZ - IOPscience

located in geopolymer concretes, with a huge quantity of GGBFS and less SS to SH ratio within the combinations [11]. Geopolymer Concrete is an alternative material to OPC, but due to its viscosity nature, the problem causes in compaction. To overcome the issue, Self Compacting Geopolymer Concrete has been introduced.

ادامه مطلب

Structural Concrete: Early View

Structural and economical performance of reinforced concrete frames with Dual-Phase and TempCore® steel rebars in uncorroded and corroded conditions. Silvia Caprili, Francesca Mattei, Walter Salvatore., Version of Record online: 19 September 2021.

ادامه مطلب

THE WORKABILITY AND COMPRESSIVE STRENGTH OF …

by Textile Mill Sludge beyond 35% along with an estimated quantity of plasticizer in concrete, the compressive strength and workability decreases. The utilization of Textile Mill Sludge of concrete as a substitute will helps us to reduce negative impacts of sludge waste and …

ادامه مطلب

Study on Effect of Chemical Composition of Geopolymer to ...

1 Study on Effect of Chemical Composition of Geopolymer to Improve Sludge by Using Fiber Materials Chien Minh VU 1, Tuan Anh LE2, Tomoaki SATOMI1 and Hiroshi TAKAHASHI 1 Graduate School of Environmental Studies, Tohoku University, Sendai, Japan 2 Ho Chi Minh City University of Technology, Ho Chi Minh, Vietnam (Received 10 January 2017; received in revised form 8 May 2017; accepted 16 …

ادامه مطلب

FLEXURAL PERFORMANCE EVALUATION OF VARIOUS …

mance concrete construction with free-form designs [7–15] A textile reinforced geopolymer (TRG) is a relati-vely new composite material. To date, many works have been performed to evaluate the effectiveness of the use of a textile reinforced geopolymer matrix composite for

ادامه مطلب

Palm Oil Clinker as a Waste by-Product: Utilization and ...

A geopolymer concrete that contain POC as coarse aggregate was designed and evaluated. According to the results, 41.5 MPa was the highest compressive strength achieved at 28 days curing with a density range of 1910–2172 kg/m3. Splitting tensile …

ادامه مطلب

Strength Enhancement of Geopolymer-Based Concretes by ...

As a relatively new material, geopolymer concrete offers benefits as a construction material for sustainable development. It utilizes waste materials such as recycled concrete sludge, fly ash,etc. To reduce CO2 emission, geopolymer concrete is expected to replace the traditional Portland cement based concrete. It's reported that geopolymer based concrete releases only 1/6 CO2 compared to ...

ادامه مطلب

Utilization of industrial waste—based geopolymers as a ...

In this review, it has been found that 5–20% mixing of geopolymer, 8–12 M molarity, 25–45 °C T, 7–28 days of curing, 1.5–2.5 AA ratio and 0.35–0.85 w/b ratio are the optimal range of parameters of geopolymer which gives a significant improvement in the geotechnical properties of soil.

ادامه مطلب

1. Introduction - Hindawi

One of the most common textile sludge disposal alternatives is incineration [21]. Textile sludge ash has been used as an additive and substitutive ingredient in cement-based materials [22 – 24], blocks [5], and bricks [21, 25, 26]. However, the properties of sludge are varied from factory to factory due to the difference in use and dosage of ...

ادامه مطلب

Mr.K.Ramamoorthy – CK College of Engineering and Technology

Ramamoorthy B.Tamilamuthan "Flexural behaviour of Prestressed Geopolymer Concrete Beams" IJRESTsVol.10 Issue No Mar 16; KRamamoorthy "An Experimental study on partial replacement of textile sewage sludge in concrete as fine Aggregate" IJRST Issue No 11 Mar 17

ادامه مطلب

Volume-9 Issue-2S2 - International Journal of Innovative ...

Optimum Utilization of Locally Available Waste Materials in Enhancing the Properties of Concrete: 21. Authors: A. Chithambar Ganesh, M. Muthukannan: 89-92: Paper Title: Effect of Polypropylene fibers over GGBS based Geopolymer Concrete Under Ambient Curing: 22. Authors: Jagan Sivamani: 93-96: Paper Title:

ادامه مطلب

A study on engineering properties of textile ETP sludge ...

sludge based concrete with a partial replacement for cement and the compatibility of the textile ETP sludge with admixtures was observed. From the present experimental work it …

ادامه مطلب

Use of Plastic Granules in Geopolymer Concrete as a ...

In geopolymer concrete there is no use of cement which will reduce the use of cement. As plastic takes very long time to degrade, which can have adverse effects on environment such as polluting soil and sea, death of animals. Use of plastic granules in this geopolymer concrete will help in reducing plastic pollution in environment. ...

ادامه مطلب

Latest Civil Engineering Seminar Topics 2021

Are you looking for the Latest Civil Engineering Seminar Topics? If yes, then you have come to the right place, Because every civil engineering student and diploma course students must require to present and submit a seminar report on the latest trends happening in the technology and industry trends within the academic curriculum.

ادامه مطلب

BIO DATA Name : Dr.K.CHINNARAJU

UGC – CPEES PROJECT (Utilization of Textile Sludge in combination with Fly Ash for the Production of Construction Materials), Rs. 30 00 300/- ... on strength of geopolymer concrete", 2012, International Conference on Sustinability Challenges and Advances in Concrete Technology.

ادامه مطلب

Incineration of Textile Sludge for Partial Replacement of ...

One of the most common textile sludge disposal alternatives is incineration . Textile sludge ash has been used as an additive and substitutive ingredient in cement-based materials [22–24], blocks, and bricks [21, 25, 26]. However, the properties of sludge are varied from factory to factory due to the difference in use and dosage of the dye ...

ادامه مطلب

Flexural Behavior of Hybrid PVA Fiber and AR-Glass Textile ...

However, due to use of cement rich matrix the existing development of textile reinforced concrete (TRC) need to be more environmental friendly by replacing cement based binder with geopolymeric binder. This paper presents a first study on the flexural behavior of alkali resistant glass fiber textile reinforced geopolymer (TRG).

ادامه مطلب

Technical Feasibility Study on Utilization of Textile ...

Rubber Mould Textile Sludge Paver Block (RMTSPB) contains cement, Textile ETP Sludge, Fine aggregate, semi grit and admixture is utilized. In Rubber Mould Textile Sludge Paver Block (RMTSPB) cement is substituted with textile ETP sludge by 5%, 10%, 15%, 20%, 25%, 30%, 35% and 40% by weight of cement.

ادامه مطلب

[PDF] Utilization of sludge in manufacturing Energy ...

Utilization of sludge in manufacturing Energy Efficient Bricks. The bricks are obtained by moulding clay in rectangular blocks of uniform size and then by drying and burning these blocks. Burnt clay bricks have good resistance to moisture, insects and erosion and create a good room environment. They are medium in cost and have medium to high ...

ادامه مطلب

Desludging Wastewater Ponds Using Geotextile Dewatering Bags

Guidelines for the Utilization and Disposal of Wastewater Sludge – Volume 3. (2007). Requirements for the on-site and off-site disposal of sludge of wastewater sludge. WRC Report No. TT 349/08. 2007. Mastin, B. J., Lebster, G. E., & Salley, J. R. (2008). Use of Geotube® dewatering containers in environmental dredging.

ادامه مطلب

Utilization of Silicon Carbide Sludge as Metakaolin-Based ...

The recycling of SiC sludge material is crucial for resource reutilization and environmental protection. In the current study, the effect of the mass ratio between the Na2SiO3 and sodium hydroxide (NaOH) solutions (NS/SS ratio) and the effect of SiC sludge on metakaolin geopolymers was comprehensively investigated to determine the underlying performance of the geopolymerization system.

ادامه مطلب